Westerbeke 7.0BCG Operator's Manual

Operator's Manual for Westerbeke 7.0BCG Inverter, Portable Generator (55 pages)

Specifications:

1347/1347423-70_bcg.pdf file (06 Nov 2023)
  • Manufacturer: Westerbeke
  • Category of Device: Inverter, Portable Generator
  • Document: 7.0BCG, File Type: PDF Operator's Manual
  • Updated: 06-11-2023
  • Count of Pages: 55
Download 7.0BCG Manual (55 pages)

Read Document Online:

Data: UPD 6th November 2023

Westerbeke 7.0BCG Inverter, Portable Generator PDF Operator's Manual (Updated: Monday 6th of November 2023 08:56:20 PM)

Rating: 4.5 (rated by 5 users)

Compatible devices: WTA-15-514, WMD 7.7, 3.5 SBCG, 7.6kw-60Hz EDT, 7.6 kw EDT, 10TWO, 6.5 MCG 60HZ, 7.5 MCGA.

Recommended Documentation:

Text Version of Westerbeke 7.0BCG Manual (Summary of Contents)

(Ocr-Read of the Westerbeke 7.0BCG Document (Main Content), UPD: 06 November 2023)
  • 39, Westerbeke 7.0BCG WIRING SCHEMATIC #38028 I 2 voe BATTERY ..------------------i+ 1111i.::-:__-------------, START SOL.ENOIO r -1 I I CIRCUIT EIR£AKER : I ao AMP ._ __ J STOP SWITCH FUSE 8AMP 1 TBH 1.....--- OIL PRESSURE SWITCH EXHAUST TEMP. SWITCll FU PUMP BALLAST .,_ __ +_f'R"""&quo…

  • 9, PARTS IDENTIFICATION 20AmpDC Circuit Breaker Lube Oil Dipstick Fresh Water Coolant FUI Model Data Tag Oil Pressure --~ Switch ... / Heat Exchanger . Control Panel 8A &15AFUSES~ AC Connections--- Outlet Gasdenser Lube OH Fill Exhaust Temperature Switch Air lntak~ Flame Arrester Lube Oil Drain Hose lwiWESTER…

  • 5, Westerbeke 7.0BCG SAFETY INSTRUCTIONS ACCIDENTAL STARTING A WARNING: Accidental starting can cause Injury or death! a Disconnect the battery cables before servicing the engine/ generator. Remove the negative lead first and reconnect it last. a Make certain all personnel are clear of the engine before starting. a Make certain all covers, …

  • 17, Westerbeke 7.0BCG BREAK•IN PROCEDURE/DAILY OPERATION BREAK·INPROCEDURE After the.generator has been started, check for proper operation and then encourage a fast warm-up. Run the generator between 20% to 60% of full load for the first 10 hours. A CAUTION: ·Do not attempt to break-in your genera- t…

  • 7, INSTALLATION When installing WESTERBEKE engines and generators it is important that strict attention be paid to the following information: CODES AND REGULATIONS Strict federal regulations, ABYC guidelines, and safety codes must be complied with when installing engines and generators in a marine environment. SIPHON…

  • 16, Westerbeke 7.0BCG OPERATING INSTRUCTIONS ABNORMAL STOP An abnormal stop is one in which the generator ceases to run and comes to a stop as a result of an operating fault which may cause damage to the engine, the generator, or create an unsafe operating condition. The fault stop conditions are: 1. Overspeed co…

  • 46, Westerbeke 7.0BCG SHORE POWER TRANSFER SWITCH 120 VOLT/60 HER'll TWO WIRE CONFIGURATION Switching Shore Power to Generator Power If the installer connects shore power to the vessel's AC circuit, this must be done by means of the Shore Power 'Il.'ansfer Switch .. Set the transfer switch shown in the d…

  • 48, LAY·UP & RECOMMISSIONING Starter Motor Lubrication and cleaning of the starter drive pinion is advisable, if access to the starter pennits its removal. Make sure the battery connections are shut off before attempting to remove the starter. Take care in properly replacing any electrical …

  • 23, COOLING SYSTEM CHANGING COOLANT The engine.'s coolant must be changed according to the MAINTENANCE SCHEDULE. If the coolant is allowed to become contaminated, it can lead to overheating problems. A CAUTION: Proper cooling system maintenance Is critical; a substantial numbe1 of engin…

  • 36, ENGINE ADJUSTMENTS SPARK PLUGS The spark plugs should be cleaned and regapped after the first 50 hour break-in period, then inspected every 250 hours thereafter and replaced as needed. AWARNING: Do not remove the spark plugs while the engine is hot. Allow the engine to cool before removing them. Spark …

  • 20, Westerbeke 7.0BCG MAINTENANCE SCHEDULE NOTE: l :H t''ngtne hourtli1/'!er );;UUtte Jo /p'.!,_ r1>ur r·n,~ine i!uuts· tir H'\:01'1 e11gi11e huun r1111nmg ti11n'. ,-i -----,,--·---~-~·-~--~-' 1 - ---r- ------"----- I CHECK j HOURS Of OPERATION _j I SCHEDULED EACH …

  • 22, Westerbeke 7.0BCG COOLING SYSTEM RAW WATER INTAKE STRAINER NOTE: Always install the strainer at or below the waterUne so the strainer will always be self-priming. A clean raw water int.alee strainer is a vital component of the engine's cooling system. Include a visual inspection of this strainer when making your periodic en…

  • 35, Westerbeke 7.0BCG ENGINE ADJUSTMENTS NOTE: WESTERBEKE recommends that the following engine adjustments be perfonned by a competent engine mechanic. The information below is provided to assist the mechanic. ENGINE SPEED (HERTZ) ADJUSTMENT Governor The belt-driven, mechanically operated governor maintains the engine's rpm under various load con…

  • 15, Westerbeke 7.0BCG OPERATING INSTRUCTIONS STARTING 111EGENERATOR A WARNING: .. Ventilate the generator compatfment for a minimum of five mlnut• prior to starting. The WJntilatlng blowers remove any explosive gasoline fumes from the generator comjlarlment and bilges~ •. 1. Depress the ON switch and hold it down (5-15 sec~nds)…

  • 50, · BCG GENERATOR SPECIFICATIONS AC GENERATOR General Voltage BrusNesa. four-pole, l'IMJMng fielcl. Self 8lCCiting. Capacitor salUlaled field excitation. Pfe.lubricaled. single-beamgdeslgn. Reca•ledable 120 volts ~ 120 vdls - 60 hartz 220 valls - 50 hertz. Vollage regulation: :!:5% no-load to f!M-load. Frequency regUal…

  • 12, Westerbeke 7.0BCG GASOLINE FUEL, ENGINE OIL AND ENGINE COOLANT ENGINE COOLANT ·A CAUTION: Ilse unleaded 89 Octaae gasal/ae or higher. Etbana/ gasa/lne'must not exceed E10 (100/o). BefSDll°'e ·wif~ hillher.1111rce11tages of·Ethaaol are, not a~/e;far.·use.!R·tbesemo*/s and caa void the warranty. Gaisoline With an ETHANOL …

  • 32, Westerbeke 7.0BCG BATIERY CHARGING CIRCUIT INTEGRAL CONTROLLER (J.C.) The Integral Controller (l.C.) is an encapsulated, solid-state unit that supplies a DC charging voltage to the generator's starting battery while the generator is opening. Charging Voltage: 13.0 - 14.0 volt.$ DC Charging Amperage: 0 -10.0 amps DC A separate g…

  • 27, Westerbeke 7.0BCG ENGINE OIL CHANGE Engine Oil Change 1. Draining the Oil Sump. Discharge the used oil through the sump drain hose (attached to the front of the en!iine) while the engine is warm. Drain the used oil completely, replace the hose in its bracket, and replace the end cap securel_y. WARM THE ENGINE. SHUTDOWN AND DRAIN . …

  • 1, -(£ft.It " ·_j ~ . ~ _,. } "' i. "' ' 0 'q _ll1.o"-'. OPERATORS MANUAL 7 .0 BCG and 7 .0 BCGA • 60Hz . · · 5.0 BGG•5\ll-z GASOLINI·· •GEi-TORS SINGLE PHASE PUBLICATiON Nb~ oa~ii~o: · .. ,· . .REVISIQN 3 OCTOBER 201e ~ 'WESIERBEKE .…

Similar Searches:
  • Westerbeke 7.0BCG User Manual
  • Westerbeke 7.0BCG User Guide
  • Westerbeke 7.0BCG PDF Manual
  • Westerbeke 7.0BCG Owner's Manuals

DOC-66956e29:

Recommended:
Olde English Paver Outdoor Fireplace Kit, CHC-LCD-30FM, True Blue ST1, Wireless Service Module 2

TOC 1000, 02010-1, 20GSBB-6714A, HW5500 - 5500 Portable Generator, PIXIE RP10 Series
  • Operating Instructions & Parts ManualDayton Professional-Duty Electric GeneratorsDescriptionDayton professional-duty generators are rugged and compact to provide dependable,trouble-free service. The alternators are brushless with revolving fields. Honda gasolineengines provide long life under heavy use. Overhead valves (OHV) provide high perfor-mance with lower fuel consumption. These engines are governed t ...

    Model & Doc Type: 3WY47 40

  • DS7000Q GENERATORThis manual provides information regarding the operation and maintenance of these products. We have made every effort to ensure the accuracy of the information in this manual. We reserve the right to change this product at any time without prior notice.5800 Ontario Mills PkwyOntario, CA 91764 USAwww.duromaxpowerequipment.comCall our Customer Care Team Toll Free 8-5pm PST Mon-Fri 844-DUROMAXUser ManualREV: DS7000Q-05252018 ...

    Model & Doc Type: DS7000Q 56

  • EC DECLARATION OF CONFORMITY4HE MANUFACTURER OF THE PRODUCT COVERED BY THIS $ECLARATION IS.!0 "RANDS ,TD.APIER (OUSE 5NIT  #ORUNNA #OURT7ARWICK 5NITED +INGDOM #6 (14HE MANUFACTURER HEREBY DECLARES THAT THE MACHINE AS DETAILED IN THIS DECLARATION FULFILS ALL THERELEVANT PROVISIONS OF THE -ACHINERY $IRECTIVE AND OTHER APPROPRIATE DIRECTIVES AS DETAILED BELOW4HE MANUFACTURE FURTHER DECLARES THAT THE MACHINE AS DETAILED IN THIS DECLARATION WHERE APPLICABLE� ...

    Model & Doc Type: IM1500I 20

  • INTELLICHLOR®SALT CHLORINE GENERATOR Model IC15 INSTALLATION AND USER’S GUIDE REGISTRATION NO. 30931 PEST CONTROL PRODUCTS ACT DOMESTIC Pentair Water Pool and Spa, Inc. 10951 West Los Angeles Ave., Moorpark, CA 93021 USA. (800) 831-7133 (800) 553-5000IMPORTANT SAFETY INSTRUCTIONS READ AND FOLLOW ALL INSTRUCTIONS SAVE THESE INSTRUCTIONS KEEP OUT OF REACH OF CHILDREN ...

    Model & Doc Type: IC15 72

Additional Information:

# Brand Model Document Type/File Pages File Size Last Checked
1 Natural Ozone
PURIMAX 5G
12 12/02
2 Parker
CVX0260B
24 09/11
3 Trilogy Communications
Mentor RG 360-00-05
121 29/08
4 Kobelt
HPU400 Series
33 16/12
5 Wallenstein
EU7200E
42 09/02
6 Opitec
103.410
5 01/12
7 Cummins Power Generation
Onan MicroLite 4000 Series
49 13/12
8 Texas A/S
MPC 1500
46 11/01
9 Onan
MEP-003A
163 04/10

Product Types by Westerbeke:

Popular Right Now:
# Brand Model Document (PDF) Pages Size Check Date
1 Mazda
2014 MX-5 Miata
16 06.10.2023
2 Make Noise
DPO
16 06.09.2023
3 Wagan
SKU 47801
1 0.18 Mb 25.12.2023
4 Bosanova
LTC-600
2 0.08 Mb 16.10.2023
5 Philips
HTS5120/12
12 2.17 Mb 15.02.2024
6 Black Box
IC476A-F-R2
25 0.2 Mb 11.09.2023
7 Panasonic
TX-28MD3F
41 13.01.2024
8 Sony
PCG-K76P
6 0.85 Mb 07.09.2023
9 Koblenz
U-75
12 02.09.2023
10 Philips
AZ1833/12
2 0.26 Mb 02.01.2024

Operating Impressions, Questions and Answers: