-
1, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Titan Lift Manual PART #: F-600TLNA US PATENT NUMBER: [D507,769 S] 600 LB. [272 kg] MAXIMUM WEIGHT CAPACITY MANDATORY LEAVE THIS MANUAL WITH LIFT OWNER Read and follow all instructions. Lift safety can only be ensured if installed and operated according to these instructions. • NEVER permit children to play on or around the lift • Do not allow children to use the lift without adult supervision • NEVER apply direct …
-
2, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Titan Lift Titan Components 1. The Titan Main Assembly 2. Control Arm 3. Lifting Arm 4. Seat Arm 5. Footrest 6. Actuator 7. Handset 8. 24V Battery Table of Contents PAGE DESCRIPTION PAGE DESCRIPTION 2 Titan Components 9 Troubleshooting Guide 3 ADA Installation Guidelines 10 Proper Care of Pool & Spa Lifts 4 Anchor Installation: New Construction 11 Titan Parts List 5 ADA Fixing Insert Insta…
-
3, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Installation: ADA Guidelines [40.6cm] 16" MIN [91.4cm] 36" [122cm] 48" [73.7cm] 29" [30.5cm] 12" ADA REQUIRED CLEAR DECK SPACE POOL WALL WATER FIGURE 1 ADA Requirements: The Titan Lift is ADA Compliant. The installation must meet the following requirements: • Clear deck space dimensions (see FIGURE 1) • Installed a minimum of 21 inches from the p…
-
4, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Anchor Installation: New Construction or Retro-Fit You may need to saw cut and remove a portion of an existing pool deck in order to achieve the 11 inch depth footing requirement. Aqua Creek does NOT recommend a core drill installation for this lift. To properly install this anchor, you will need to have a concrete footing comprised of 2500 psi concrete that is 11 inches deep and 4 feet - 4 inches square and reinforced with rebar. Refer to Figures A and B bel…
-
5, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 ADA Fixing Insert Installation (Commercial Applications) STEP 1: INSTALLING THE LIFT ON THE POOL/SPA DECK 1. Due to the indexed anchor and keyed base of the lift, we recommend installation of the xing insert after the concrete has cured and you are ready to install the lift into the anchor. 2. Place the main assembly in the anchor and turn until the locking pin on the shaft of the lift lines up and drops into the locking pin slot in the anchor. DO N…
-
6, Aqua Creek F-600TLNA Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Titan Assembly Instructions STEP 2: INSTALL LIFTING ARM Locate the LIFTING ARM and the following hardware: • (1) 1/2” x 3” SHOULDER BOLT • (1) 3/8” x 2” SHOULDER BOLT • (1) 5/16” FLAT WASHER • (1) 5/16” NYLOCK NUT • (1) 3/8” FLAT WASHER • (1) 3/8” NYLOCK NUT Remove the shipping strap and all packing from the LINEAR ACTUATOR. Connect the LIFTING ARM between the MAST and the LINEAR ACTUATOR as shown in t…
-
7, Aqua Creek F-600TLNA Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Titan Assembly Instructions 3/8" NYLOCK NUT (2) 3/8" FLAT WASHER (2) SEAT ARM 1/2" X 3" SHOULDER BOLT (2) CONTROL ARM LIFTING ARM STEP 4: INSTALL SEAT ARM Locate the SEAT ARM and the following hardware: • (2) 1/2” x 3” SHOULDER BOLT • (2) 3/8” FLAT WASHER • (2) 3/8” NYLOCK NUT Install the SEAT ARM at the ends of the CONTROL ARM and LIFTING ARM as shown in the gure to the left. Tighten the NYL…
-
8, Aqua Creek F-600TLNA Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 QUICK RELEASE PIN FOOTREST TUBE (ADJUSTABLE) SEAT ASSEMBLY 24V BATTERY CONTROL BOX HANDSET CONTROL Titan Assembly Instructions STEP 6: INSTALL THE FOOTREST Locate the FOOTREST ASSEMBLY and install it on the seat as shown below. The QUICK RELEASE PIN is attached to the SEAT ASSEMBLY with a lanyard (cable). Pull out the pin and slide the FOOTREST ASSEMBLY into the slot and line up one of the holes o…
-
9, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Basic Troubleshooting Problem: The lift won’t move. Solution: 1. Make sure the battery is properly seated: You should hear a click when the battery is properly seated on the control box or charger. Click! NOT Properly Attached: Note: the white bracket is in front of the silver clip, which will not allow for an electrical connection Properly Attached: Note: the white bracket is behind the silver cli…
-
10, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Proper Care of Pool & Spa Lifts PROCEDURE DAILY WEEKLY MONTHLY Wash down lift with fresh water and dry with clean, soft, non-abrasive cloth. Recharge battery. Run the lift through a complete test cycle to verify it is functioning properly. Visually inspect lift for damage, corrosion, and loose or missing hardware. Check all contact points for damage and/or corrosion. Repair, clean, and apply dielectric grease to all…
-
11, Aqua Creek F-600TLNA Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Titan Parts List ITEM # QTY PART # DESCRIPTION 1 1 TTN-200-80 BASE ASSEMBLY 2 1 TTN-40M-70 MOTOR ASSEMBLY 3 1 TTN-400-70 MAST ASSEMBLY 4 1 TTN-500-65 LIFTING ARM ASSEMBLY 5 1 TTN-600-65 CONTROL ARM ASSEMBLY 6 1 TTN-700-66 CHAIR ARM ASSEMBLY 7 1 REV-800-20 CHAIR CRADLE ASSEMBLY 8 1 SA-0904WDCAB 22” WIDE SEAT ASSEMBLY 9 1 F-0904FRA FOOTREST ASSEMBLY 10 1 340643-00 600…
-
12, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 1 2 2 4 4 12 3 11 5 7 9 9 8 8 10 6 ITEM # QTY PART # DESCRIPTION 1 1 P-2035LEG REVB LEG/FOOTREST TUBE 2 1 P-910PL FOOTREST, PLASTIC, BLUE 3 2 SQR-1-14-20 CAP, PLASTIC, 1”X1” SQUARE 4 1 BB 1/4 X 3 BOLT, 316 SS, 1/4-20 X 3 BHSCS 5 2 WF 1/4 WASHER, FLAT, 1/4, 316 SS 6 1 NN 1/4 NUT, 316 SS, NYLOCK, 1/4”-20 2 1 4 5 5 6 3 3 ITEM # QTY PART # DESCRIPTION 1 1 P-905B CHAIR,…
-
13, Copyright © 2017 Aqua Creek Products All Rights Reserved Revised 4/14/17 Revised_1.2.2017 AQUA CREEK PRODUCTS, LLC LIMITED FIVE (5) YEAR WARRANTY: TITAN POOL LIFT (ITEM: F-600TLNA) Aqua Creek Products, LLC (a.k.a. Aqua Creek) warrants to the original end user purchaser that products manufactured by Aqua Creek, when properly installed in accordance with assembly and installation instructions, and properly used and maintained, shall be free from defects in material…
-
14, F-450BL-C Scout 2 Lockable Cover F-450SSC Scout 2 Cover (use with Solar Charger) F-720BL-C Revolution/Titan Lockable Cover F-720SSC Revolution/Titan Cover (use with Solar Charger) F-450SLEC Spa Lift Elite Lockable Cover F-450SLECS Spa Lift Elite Cover (use with Solar Charger) F-450SLUC Spa Lift Ultra Lockable Cover F-450SLUCS Spa Lift Ultra Cover (use with Solar Charger) F-BCC-11 Electronics Cover Scout, Rev, Titan, Power EZ [email protected] | www.aquacreek.com +1-406-549-0769 | 888-687-3552 UPGRADE PACKS…
