Subaru Impreza 2004 Service Manual

26, PS-70 POWER ASSISTED SYSTEM (POWER STEERING) Pipe Assembly [LHD MODEL] NOTE: It is likely that although one judges fluid leakage, there is actually no leakage. This is because the fluid spilt during the last maintenance was not completely wiped off. Be sure to wipe off spilt fluid thorough…

6, PS-50 POWER ASSISTED SYSTEM (POWER STEERING) Steering Gearbox [RHD MODEL] 6) Tighten the adjusting screw until it no longer tightens. 7) Using a wrench (32 mm (1.26 in) width across flats) or adjustable wrench with cinching boot, re- move the tie-rod. 8) Loosen the adjusting screw, and…

35, PS-79 POWER ASSISTED SYSTEM (POWER STEERING) Pipe Assembly [RHD MODEL] Fluid leaking area Possible cause Corrective action Leakage from connecting portions of pipes and hoses, numbered with (1) through (10) in figure Insufficient tightening of flare nut, catching dirt or the lik…

23, PS-67 POWER ASSISTED SYSTEM (POWER STEERING) Pipe Assembly [LHD MODEL] 3) Temporarily connect the pipe C and D to gear box. 4) Temporarily install the clamp E on pipes C and D. NOTE: Ensure the letter “8” on each clamp are diagonally opposite each other as shown in the figure. 5) Tighten…

21, Subaru Impreza 2004 PS-65 POWER ASSISTED SYSTEM (POWER STEERING) Pipe Assembly [LHD MODEL] 6) NON-TURBO MODEL (1) Remove the air intake duct. <Ref. to IN(H4SO)-6, REMOVAL, Air Intake Duct.> (2) Remove the bolt A. (3) Disconnect the pipe C from oil pump. Dis- connect the pipe D from return hose. CAUTION…

46, PS-90 POWER ASSISTED SYSTEM (POWER STEERING) General Diagnostic Table 2. MEASUREMENT OF STEERING EFFORT Step Check Yes No 1 CHECK STEERING EFFORT. 1)Stop the vehicle on a concrete road. 2)Start the engine. 3)Idle the engine. 4)Install the spring scale on the steering wheel. 5)Pull the s…