Hellenbrand Iron curtain System 2.0 Owner's Manual

3, 3 IRON CURTAIN ® 2.0 The advantages of a multi-media bed are: 1. Longer runs between backwash times. 2. Caking of the bed and breakthrough turbidity are virtually eliminated. 3. Much higher service ow rates per square foot. 4. Higher degree of clarity because of the heavier, �…

8, 8 1 ...........110269 .................... Hellenbrand Pump ........................... 1 2 ...........101631 .................... IC Pump Feet ...................................3 3 ...........102137 .................... IC Pump Feet Nut ............................3 4 ...…

21, 21 Complaint Problem Cause Solution 1a. Plug in aeration pump. (See start-up instructions - page 5.) 1b. Clean or replace shuttle valve and piston assembly 2b. Reduce water supply pressure 3b. Clean or replace solenoid assembly 4b. Clean or replace pi…

24, 24 DISASSEMBLY STEP 1. Clean external surfaces of compressor. (see Figure 1) STEP 2. Loosen and remove the 4 head screws (1) and compressor head (2). STEP 3. Carefully separate valve plate (5) from head. STEP 4. Remove both head O-rings (3 and 4) and discard. Carefully remove …

17, Hellenbrand Iron curtain System 2.0 17 U.S. Patents #7,156,995 B2 7,491,321 & 7,638,063 Step 2. Aeration Operation Air Recharge Cycle When energized, the air pump sends air through the solenoid valve into one end of the shuttle valve. Once air pressure in the shuttle valve is greater than the water supply pressure a…

6, 6 Aeration Control Center Your new IC-2.0 Aeration Control is factory pre-set to cycle the air compressor every 500 gallons or approximately once every 24 hours and during lter regeneration. If chem feed option is used, only one means of initiating air recharge will be available, s…