Char-Broil 09201555-05 Product Manual

4, THE HEAT OF THE COALS seconds you can hold the palm of your hand 4 inches above the coals temperature range (Fº) visual cues HOT COALS 2 400 to 450 barely covered with gray ash; deep red glow MODERATELY HOT 375 to 450 thin coating of gray ash; deep red glow MODERATELY HOT COALS 4 325 to 375 si…

9, Char-Broil 09201555-05 On 3 each short leg, slide one onto axle, followed by a wheel, then another . Slide a into the hole at the end of the axle. 7/16” flat washer 7/16” flat washer hitch pin Wheel 7/16" Flat washer Axle Short leg Hitch pin 7/16” Flat washer Hitch pin 9 Slide 4 short legs …

12, 12 9 Handle bracket Hitch pin Handle Handle rod Assembly . . . While holding handle in position between handle brackets, slide rod into one bracket, through handle, and out through other bracket. Secure at each end of rod with . Repeat process to assemble firebox handle.hitch pins Handle 10 …

11, 11 7 Smoke Chamber Attach smokestack to end of smoke chamber by sliding stack into smokestack receiver. While holding the smokestack in a vertical position, tighten the 3/8-16x3/4" hex head bolt in the nut that is welded to Smokestack Smokestack To attach damper to firebox …

2, DANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING WARN…

8, ASSEMBLY 8 FIRST, GET A HELPER! This unit is heavy and requires a second person for lifting and moving. NEXT, pick a suitable location to work. Open the carton and slit the corners so that the carton lays flat. This will give you a protective surface during assembly. Remove the cart…