Char-Broil Classic C-59G4 Product Manual

10, Char-Broil Classic C-59G4 6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use too…

25, 12 #10-24x1/2" Machine Screw Qty. 4 5mm Flat Washer Qty. 4 5mm Lock Washer Qty. 4 • Attach handles to doors with #10-24x1/2" machine screws, 5mm flat washers and 5mm lock washers . • Insert hinge pin on bottom shelf into hole in door. Press upper hinge pin in front door brace, alig…

29, Troubleshooting (continued) Problem Burner(s) will not light using ignitor. (See Electronic Ignition Troubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)…

3, WARNING Installation Safety Precautions • Use grill, as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. If your grill is Dual Fuel ready, a conversion kit must be purchased for use with natural gas. • Grill installation must conform with local codes,…

9, WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1.LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2.Turn all control knobs to the OFF positi…

15, This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the …