Dacor OB36 Installation Instructions Manual

24 pages manual for Dacor OB36 Grill

Dacor OB36 Grill Manual

Manufacturer: Dacor

Category of Device: Grill

Document: Dacor OB36 Installation Instructions Manual, File Type: PDF

Count of Pages: 24

Download Dacor OB36 Manual

Dacor OB36 Grill Manual, Summary of Contents:

# Screenshot Page Сontent Preview
1 Dacor OB36 Page 1
Page No1 Summary

Dacor OB36 Manual Page 1 Page 1 Installation Instructions Epicure ®  Outdoor Grill Models: OB36, OB52, OBS36 and OBS52 Part No. 102032  Rev. L TesTed in accordance wiTh The laTesT ediTion of   ANSI Z21.58 2006 ● cSA 1.6-2006 StANdArd for outdoor cookINg gAS ApplIANceS. IN cANAdA: INStAllAtIoNS MuSt Be IN AccordANce WItH tHe curreNt cAN/cg A-B149.1. NAturAl gAS INStAllAtIoN code cAN/cg A-B149.2. propANe INStAllA...

2 Dacor OB36 Page 2
Page No2 Summary

Dacor OB36 Manual Page 2 Page 2 Before You Begin... Customer Service Information all specifications subject to change without notice. dacor   assumes no liability for changes to specifications. Important: • installer: In the interest of safety and to minimize problems, read these installation instructions completely and care- fully before you begin the installation process. Leave these installation instructions with the customer. • customer: Keep these installation instructions for future reference and the local electrical inspector’...

3 Dacor OB36 Page 3
Page No3 Summary

Dacor OB36 Manual Page 3 Page 3 1 Important Information About  Safety Instructions •  The  important safety instructions and warnings in  these instructions are not meant to cover all possible  problems and conditions that can occur. Use common  sense and caution when installing, maintaining or oper- ating this or any other appliance. •  Always contact Dacor Customer Service about prob- lems and conditions that you don’t understand. Safety Symbols and Labels  danger Immediate hazards that  will result in severe pers...

4 Dacor OB36 Page 4
Page No4 Summary

Dacor OB36 Manual Page 4 Page 4 2 Important Safety Instructions •  Read the use and care manual completely before  using this appliance. •  Use this appliance only for its intended use as  described in the use and care manual. Use it only to  cook food. It is not designed for commercial, indus- trial or laboratory use. •  If you receive a damaged product, immediately con- tact your dealer or builder. Do not install or operate  an appliance that has been damaged or dropped. •  This appliance must be properly installed and gr...

5 Dacor OB36 Page 5
Page No5 Summary

Dacor OB36 Manual Page 5 Page 5 3 Important Safety Instructions  warning •  Do not leave children alone or unattended in the area  around the appliance. Do not allow children to oper- ate it, play with the controls, pull on the handle or  touch other parts. •  Do not store items of interest to children on top of  or above the appliance. Children could be burned or  injured while climbing on it. •  Keep the ventilation openings for the LP cylinder free  and clear from debris. •  Non-stick coatings, when h...

6 Dacor OB36 Page 6
Page No6 Summary

Dacor OB36 Manual Page 6 Page 6 4 9 1/8" (23.2 cm) 23 3/4" (60.3 cm) 26 1/2" (67.3 cm) 27” * (68.6 cm) 36" (91.4 cm) 25 1/8" (63.8 cm) Product Dimensions Planning the Installation 9 1/8" (23.2 cm) 23 3/4" (60.3 cm) 26 1/2" (67.3 cm) 27" * (68.6 cm) 52" (132.1 cm) 25 1/8" (63.8 cm) * Total depth from back to front of handles is 30” (76.2 cm) oB36 and oBs36 oB52 and oBs52 Product tolerances: ±1/16 (±1.6 mm)  unless other wise specified ...

7 Dacor OB36 Page 7
Page No7 Summary

Dacor OB36 Manual Page 7 Page 7 5 Planning the Installation Location Planning - General Gas and Electric Power Requirements •  Prior to installation, the gas supply for natural gas or  whole house LP installations must meet the specifica- tions below. •  For natural gas or whole house LP installations, have  a qualified plumber or gas fitter install a 3/4 inch (1.9  cm) or 1/2 inch (1.3 cm) gas supply line with a shut-off  valve (not included). Have it installed in an accessible  location that allows it to be shut off when the appliance  is i...

8 Dacor OB36 Page 8
Page No8 Summary

Dacor OB36 Manual Page 8 Page 8 6 Planning the Installation Location Planning - Enclosed  Cabinets •  Maintain all minimum clearances specified below and  on the facing page. •  For proper outdoor grill operation, provide a flat, level  mounting surface with minimum 3/4” (1.9 cm) thick- ness. •  All models are designed to allow installation in combus- tible or non-combustible base material structures. •  On installations without a LP cylinder tank located  below the unit, plan the installation so that the gas  shut-off valve a...

9 Dacor OB36 Page 9
Page No9 Summary

Dacor OB36 Manual Page 9 Page 9 7 Planning the Installation 3/8" (1.0 cm) ø both sides 6" x 7" (15.2 cm x 17.8 cm) utility cutout Coutertop depth 25" (63.5 cm) Cabinet depth 24" (61.0 cm) 1 1/2" (3.8 cm) Outdoor grill placement 12 1/4" (31.1 cm) OB[S]36 - 33 1/2" (85.1 cm) OB[S]52 - 49 1/2" (125.7 cm) 3/4" (1.9 cm) min. to any material for ventilation 9" (22.8 cm) max. OB[S]36 - 36 1/2" (92.7 cm) OB[S]52 - 52 1/2" (133.4 cm) 36" (91.4 cm) 8" (20.3 cm) min. to combustibles above the countertop surface, both sides cutout dimensions -...

10 Dacor OB36 Page 10
Page No10 Summary

Dacor OB36 Manual Page 10 Page 10 8 Planning the Installation Location Planning - Enclosed Cabinets (continued) Cut-out for outdoor grill Overall height Overall width Door depth: 1/4” 6 mm) oBad series accessorY doors  (oBad36 shown) Model  number overall  width overall  height cutout  width cutout  height cutout  depth OBAD20  (Single door) 19 1/2”  (49.5 cm) 21”   (53.3 cm) 16 3/4”  (42.5 cm) 18 3/4”  (47.6 cm) 3”  (7.6 cm) OBAD36  (Dual door) 35 7/8”  (91.1 cm) 21”  (53.3 cm) 33 ...

11 Dacor OB36 Page 11
Page No11 Summary

Dacor OB36 Manual Page 11 Page 11 9 Planning the Installation Location Planning - Cart Installations example of grill cart location •  Maintain all minimum clearances shown between the  appliance and all surfaces behind and to the side of the  appliance. •  Allow 26 inches minimum in front to open and close the  cabinet drawers.  •  For proper grill and drawer operation, use the outdoor  grill and cart only on a level surface. •  Side distances exclude optional shelves. Above the cooking surface, both sides: 1 1/4” (32mm) Min. ...

12 Dacor OB36 Page 12
Page No12 Summary

Dacor OB36 Manual Page 12 Page 12 10 Parts List all Models:  A   Drip tray -   B   Smoker box  C   Warming rack  D   Regulator assembly  E   Grills (2 large, 2 small)  F   Flame spreaders (2 large, 1 small)  G   Rotisserie rod and forks  H   Rotisserie motor Cleaning cream (PN A302)Models oB52, oBs52 only:  L   Side burner cover  K   Side burner grate  M   Side burner caps (2)  N   Side burner h...

13 Dacor OB36 Page 13
Page No13 Summary

Dacor OB36 Manual Page 13 Page 13 11 Installation Instructions D E H L M N P Q K F G D D Whole house natural  gas or LP regulator* LP cylinder regulator  OB36 and OBS36  (PN 72310) LP cylinder regulator OB52 and OBS52 (PN 101578) * A whole house gas regulator comes standard with natural gas models (Dacor PN 700597NG. For whole house LP  installations, replace the standard LP tank regulator and hose that come with LP models with a whole house LP regulator  (Dacor PN 700597LP). The whole house LP regulator must be ordered separat...

14 Dacor OB36 Page 14
Page No14 Summary

Dacor OB36 Manual Page 14 Page 14 12 Cart Installation - OB[S]36 Only  warning •  Attach the appliance to the cart with all of the supplied  bolts before use. •  All gas and electrical connections should be made  after the grill is installed and bolted to the cart. •  To avoid an explosion hazard, do not connect the cart  or appliance(s) to electrical power until after the gas  supply system has been checked for leaks.  iMporTanT To prevent damage to the gas regulator, install the  regulator only after the appliance ...

15 Dacor OB36 Page 15
Page No15 Summary

Dacor OB36 Manual Page 15 Page 15 13 Optional Side Shelf Installation 1.  Install the front mounting bracket for the right side  shelf. Use two (2) of the provided button head fasten- ers and two (2) lock washers. Tighten into place using  a 5/32” Allen wrench. 2.  Slide the slot on the inside of the shelf over the pin on  the mounting bracket.  3.  While holding the shelf in place, insert the pin on the  back mounting bracket into the slot on the back side of  the shelf. 4.  While holding the shelf and back mounting bracket ...

16 Dacor OB36 Page 16
Page No16 Summary

Dacor OB36 Manual Page 16 Page 16 14 3.  Install an approved flexible gas line from the regulator  to the gas shut-off valve. Gas Connection - LP Gas Cylinder Hose 1.  Connect the supplied 3/4” coupling and nipple to the  gas inlet at the back right bottom corner of the unit. 2.  Connect the included LP cylinder hose to the nipple. Connecting the Gas Gas Connection - Natural Gas  noTe •  Units equipped for use with natural gas ship with a  regulator assembly with 3/4” pipe attached and an  additional 3/4”...

17 Dacor OB36 Page 17
Page No17 Summary

Dacor OB36 Manual Page 17 Page 17 15 Installation Instructions Final Assembly and Test Assemble the Grill 1.  Open the canopy on the unit.2.  Insert the drip tray completely into the slot on the front  of the unit. 3.  Put the flame spreaders on the floor of the appliance,  inside the canopy. The large holes go toward the front  of the unit. The holes are used to light the burners in  case of power failure. Push the spreaders as far to the  right as possible, leaving an opening on the left for the  smoker box. 4. ...

18 Dacor OB36 Page 18
Page No18 Summary

Dacor OB36 Manual Page 18 Page 18 16 Installation Instructions Final Assembly and Test (cont.) LP Cylinder Installation - Some Models  warning •  The largest recommended LP cylinder size for the  rollout tank shelf on the cart is five gallons. A five  gallon portable liquid propane cylinder should be  approximately 12 inches (30.5 cm) in diameter and  18 inches (45.7 cm) high,. It must be constructed and  marked in accordance with the specification for liquid  propane (LP) gas cylinders of the U.S. Department  ...

19 Dacor OB36 Page 19
Page No19 Summary

Dacor OB36 Manual Page 19 Page 19 17 6.  If the second or third attempt to ignite the burner is  not successful then turn all burner controls to the  off  position. 7.  If the grill or cooktop fails to operate properly, make  sure that power to the electrical outlet and gas supply  are turned on and that all installation steps have been  carefully followed. Check also for a tripped ground  fault interrupter on the electrical outlet. Push in on the  RESET button.  noTe: If using an extension cord, the ig...

20 Dacor OB36 Page 20
Page No20 Summary

Dacor OB36 Manual Page 20 Page 20 18 Wiring Diagrams W iring  d iagram  - o B(S)36 ...

21 Dacor OB36 Page 21
Page No21 Summary

Dacor OB36 Manual Page 21 Page 21 19 Wiring Diagrams W iring  d iagram  - o B(S)52 ...

22 Dacor OB36 Page 22
Page No22 Summary

Dacor OB36 Manual Page 22 Page 22 20 Notes ...

23 Dacor OB36 Page 23
Page No23 Summary

Dacor OB36 Manual Page 23 Page 23 21 ...

24 Dacor OB36 Page 24
Page No24 Summary

Dacor OB36 Manual Page 24 Page 24 Dacor ● 600 Anton Blvd. Suite 1000 Costa Mesa, CA 92626 ● Phone: (800) 793-0093 ● Fax: (626) 403-3130 ● www.Dacor.com ...

Ask a Question

Do you have questions and you did not find the necessary information about Dacor OB36 in the documents presented on website? Ask other users, maybe they have an answer to your question, or they can give you the right advice in current situation. You can ask a question about the Dacor OB36 right on this page by filling out the form you see below.