DAELIM DAYSTAR - Service Manual

50, 4-12 Fuel System Pilot Screw Adjustment 1. Turn each pilot screw clockwise until it seats lightly and back it out to the specification given. Initial Opening : 2  Damages to the pilot screw seat will occur if the pilot screw is tightened against the seat. 2. Warm up the engine to …

153, 14-4 Rear Wheel/Rear Brake/Suspension ● Check the teeth of the final driven sprocket. ● Replace the worn, damaged final driven sprocket. • Check the drive chain and drive sprocket at the same time. ● Check the damper rubber. Replace the faulty, damaged, worn damper rubber. �…

28, 3-6 Maintenance  Make sure if there is no deterioration and damage in the air cleaner element. Replace damaged parts.  The element is a viscous type which contains oil. Therefore do not use compressed air to clean the air cleaner element.  Assemble the Air cleaner element in the revers…

82, 8-3 Cylinder Head / Valve Camshaft Removal  Remove the fuel tank( 4-3)  Remove the cylinder head cover bolts and cover.  Remove the timing hole cap and crank shaft hole cap out of the left crankcase cover.  Rotate the crankshaft clockwise, place the flywheel Tmark on the left cr…

60, DAELIM DAYSTAR - 6-4 Clutch, Gearshift ● Separate the clutch arm spring and o-ring from the clutch arm/lift shaft. ● Inspect the wear and damage of the lifter rod and clutch arm/lift shaft. ● Inspect the wear and damage of the clutch arm spring. Clutch Arm/Lifter Shaft Assembly ● Coat the new o…