Volkswagen GOLF - Service & Repair Manual

223, Suspension and steering 10•3 10 1081 VW Golf & Jetta 1.2 Rear suspension components 1.1 Front suspension components …

89, 6 Engine/gearbox - separation and reconnection 3 This procedure is fully described in Chapter 7, Parts A or B, as applicable. It is only necessary to refer to those paragraphs pertinent to the particular method being used. The engine must be supported on blocks, or alternatively th…

309, Volkswagen GOLF - 8 Remove the cross-head screw (3) and pull the cap (4) from the seat guide (see illustration). 9 Slide the seat fully forward and then unscrew the cap nut. Extract the circlip and fillister head screw. 10 Release the locking bar and slide the seat rearwards out of the guide rails. 11 Refitting is…

141, 17 Pressure relief valve - removal, servicing and refitting 2 1 Release the pressure in the fuel system. 2 Unscrew the non-return valve plug and remove the plug and sealing washer. 3 Take out the O-ring, plunger and O-ring, in that order (see illustration). 4 When refitting the assem…

43, 5 Locate a new gasket on the flange face then fit the pick-up tube and strainer. Insert the bolts and tighten them to the specified torque. 6 Refit the sump, timing belt and sprocket. 32 Sump - refitting 3 1 If applicable (ie. the engine has been dismantled), refit the crankshaft rear oil seal and h…

229, Refitting 5 Refitting is a reversal of removal. Ensure that the turn signal lever is in its neutral position, otherwise damage may occur in the cancelling arm. The cancelling ring tongue points to the left. Tighten the retaining nut to the specified torque. 6 On completion, reconnect …