KTM 50 SX PRO JUNIOR LC Owner's Manual

15, KTM 50 SX PRO JUNIOR LC ENGLISH 14 PERIODIC MAINTENANCE SCHEDULE 2003 Service every 5 hours Service every 20 hours M AINTENANCE WORK DONE BY KTM AUTHORISED WORKSHOPS IS NOT A SUBSTITUTE FOR CARE AND CHECKS DONE BY THE RIDER ! A clean motorcycle can be checked more quickly which saves money! Check engine for leaks ● Ch…

17, ENGLISH 16 Removing the seat The quick-release mechanism 1 allows removal of the seat without tools. Turn the quick-release device approximately 180° counterclockwise, lift the rear portion of the seat and pull the seat off backwards. When mounting the seat ensure that the hook engages …

33, ENGLISH 32 Hexagon nuts front/rear axle M12x1 30 Nm Hexagon nut swing arm bolt M12 40 Nm Clamping screw upper/lower fork bridge M8 15 Nm Screws handlebar clamp M8 20 Nm Shock absorber top/bottom M10 45 Nm Allan screw – Handlebar support M10 Loctite + 40 Nm Front brake caliper M8…

20, ENGLISH 19 Telescopic fork maintenance * The telescopic fork must be serviced at least once a year. To service the fork, proceed as follows: Prop up the motorcycle under the frame to take the load off the front wheel. Disassemble the front wheel, remove screw 1 from the brake caliper and u…

6, ENGLISH 5 Page IMPORTANT WARRANTY AND GUARANTEE INFORMATIONE ..3 IMPORTANT INFORMATION ON SAFE DRIVING FOR PARENTS........................................................................4 SERIAL NUMBER LOCATIONS ...............................................6 Chassis number .....…

22, ENGLISH 21 General information about KTM disc brakes BRAKE FLUID RESERVOIRS: The brake fluid reservoirs for the front brake is designed such that it does not need to be refilled, even if the brake shoes are worn. If the brake fluid level drops below the minimum level either the brake sy…