Webasto Thermo Top E Installation Instructions Manual

4, VW Tiguan 1313475D_EN 4 Special features are highlighted using the following symbols: The arrow in the vehicle icon indicates the position on the vehicle and the viewing angle. Specific risk of injury or fatal accidents. Specific risk of damage to components. Specific risk of fire or explo…

23, Webasto Thermo Top E VW Tiguan 1313475D_EN 23 Position 10 mm shim 2 between 34 mm dia. rubber-coated p-clamp 4. 1 M6x20 bolt, spring lockwasher 3 M6x40 spacer nut on existing thread Preparing installa- tion of coolant hoses Hose section 1 and original vehicle clamp 2 will be reused. 2 Cutting point Cutting point …

2, VW Tiguan 1313475D_EN 2 Table of Contents Validity Vehicle and engine types, equipment variants and national specifications not listed in these installation instructions have not been tested. However, installation according to these installation instructions may be possible. The installa…

21, VW Tiguan 1313475D_EN 21 Coolant on 2.0 liter TDI WARNING! Any coolant running off should be collected using an appropriate container! Route coolant hoses kink- free! Unless specified otherwise, always fasten using cable ties. Position clamps so that no other hose can be damaged! When i…

7, VW Tiguan 1313475D_EN 7 Electrical system Wiring harness pass through 1 Original vehicle wiring harness pass through Wiring harness pass through 1 Original vehicle wiring harness pass through Wiring har- ness in- stallation diagram Routing wiring harness 1 Wiring harness of heater unit and wiring h…

12, 1313475D_EN 12 VW Tiguan Preparing bracket 16 mm dia. hole in bracket 1 at position 2. Hole in bracket Premounting heater unit 1 Combustion air pipe a = 270 Discard section X Cutting combus- tion air pipe to length 1.4 and 2.0 TSI b = 70 c = 160 e = 70 Discard section X Cuttin…