Chevrolet 2009 Aveo Service Manual

35, 2009 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Engine | Engine Controls and Fuel - 1.6L (LXT) | Repair Instructions | Document ID: 2097105 Fuel Tank Draining Special Tools Warning: Never drain or store fuel in an open container. Always use an approved fue…

110, 2. Install the EGR pipe mounting bolts to the EGR valve. Tighten Tighten the EGR pipe to EGR valve mounting bolts to 10 N·m (89 lb in). 3. Lower the vehicle. 4. Install the EGR pipe mounting bolts to the intake manifold. Tighten Tighten the EGR pipe to intake …

73, Chevrolet 2009 Aveo 7. Install the EVAP canister vapor pipe. 8. Install the EVAP canister vapor pipe mounting screws and cover. 9. Install the EVAP canister vapor pipe plastic bolt and cover. 10. Lower the vehicle. Page 6 of 8 Document ID: 2098085 7/5/2010 http://localhost…

86, 4. Disconnect the spark plug wire from the coil (2). Installation Procedure 1. Install the spark plug wire on the coil (2). 2. Install the spark plug wire (1) at each spark plug. Caution: If the boot to wire movement has occurred, the boot will give a false visual imp…

56, 3. Install the fuel pump access cover. Refer to Fuel Sender Assembly Replacement. 4. Install the fuel pipe. 5. Install the fuel pipe mounting screws and cover. Page 6 of 8 Document ID: 2098079 7/5/2010 http://localhost:9001/si/showDoc.do?docSyskey=209807…

69, 2. Remove the EVAP canister front tube from the EVAP canister purge solenoid valve and the EVAP canister vapor pipe. 3. Disconnect the EVAP canister pipe from the EVAP canister vapor rear tube. Page 2 of 8 Document ID: 2098085 7/5/2010 http://localhost:9001/s…