Arctic Cat ZR 5000 2015 Operator's Manual

12, 8 The icon should illuminate each time the ignition switch is turned to RUN or START, and it should go out when the engine starts. If the icon illuminates while the engine is running, oil pressure has been lost and the engine will auto- matically shut off. If oil pressure is lost, che…

54, 50 Adjusting Ski Stance  NOTE: Local laws and/or regula- tions as to maximum width of the ski stance on these snowmobiles may be applicable. Always comply with the maximum width laws and/or reg- ulations when adjusting ski stance.  NOTE: Ski stance can be increased/ decreased…

33, 29 The longevity and safety of the snowmo- bile can be increased by making periodic checks of the items in the preceding checklist. If, at any time, abnormal noises, vibra- tions, or improper working conditions of any component of this snowmobile are detected, DO NOT OPERATE THE SNOWMOBILE.…

30, Arctic Cat ZR 5000 2015 26 Lubrication Chain Case  NOTE: The snowmobile must be on a level surface for this procedure. 1. Check the lubricant level in the chain case by using the sight glass. 0746-115  NOTE: The correct level is when the lubricant is at least halfway up in the sight glass.  NOTE: Addin…

44, 40  NOTE: Changing one pad at a time will prevent one piston from pushing out the other piston from the caliper. 6. Measure the thickness of the brake pad. The brake pad thickness must be greater than 5.0 mm (0.20 in.). If the brake pad thickness is less than specified, replacement of both …

35, 31 Changing Engine Oil/ Filter  NOTE: Recycle or properly dis- pose of the used engine oil.  NOTE: The access panels and hood must be removed for this procedure. 1. Park the snowmobile on a level sur- face; then start the engine and allow it to warm up for 5-10 minutes, or if…