Arctic Cat Cougar Service Manual

263, FUEL SYSTEM-FUEL-INJECTED MODELS 7. After assembly is complete, tum the ignition switch ON, but do not start the engine. Turning on the ignition switch will energize the fuel pump for about 5 seconds. 8. Check for fuel leaks. WARNING Do not start the engine if there…

200, 190 8. Check the crankshaft threads for stripping, cross threading or other damage. Have threads repaired by a dealer or machine shop. 9. Check the woodruf key seat (Figure 104) in the crankshaft for cracks or other damage. If the key seat is damaged, refer service to …

466, 456 24. Move the shock rod slowly up and down a few times to remove any air trapped around the piston. Keep the piston below the level of the oil. 25. Check the oil level and make sure the oil level is still 1.5 in. from the top of the body. 26. Lubricate the floati…

500, Arctic Cat Cougar 490 WIRING DIAGRAMS MAIN HARNESS 1998 PANTERA AND EXT EFI DLX Dimmer/ brake switch Electric start! key switch Temp sensor D-RJW----. Right hand warmer l Hood harness R w L ... .. "' Gr RIW 0 R/L I Thumb warmer switch ~ Thumb f warmer I GIB- y ..--…

434, 424 d. Reinstall the housings for throttle and brake control. Make sure all controls operate properly. Handlebar Grips RemovaVInstallation lA. Observe the following when replacing handlebar grips not equipped with a heating element: a. Grips can be removed easil…

209, ENGINE 199 crankcase halves, but service is usually accom- plished in conjunction with other engine service. A kit (part No. 0644-084) is available from Arctic Cat for rebuilding the coolant pump on liquid-cooled models. 1. On liquid-cooled models, remove the cooling pump impell…